THERMODYNAMIC ANALYSIS OF RECUPERATIVE AND REHEAT BASED ON ORGANIC RANKINE CYCLE FOR HIGH-TEMPERATURE WASTE HEAT RECOVERY
DOI:
https://doi.org/10.21776/jrm.v14i1.1310Keywords:
Organic Rankine Cycle (ORC), Refrigerants, Cycle Tempo, REFPROP, Waste HeatAbstract
Heat recovery from available waste heat is an essential method in renewable energy processes due to the ability to generate electricity by using Organic Rankine Cycles (ORC). The process model is developed with the Cycle Tempo software. Fluid properties were analyzed with Reference Fluid Properties (REFPROP) software. This research presents a thermodynamic comparison of the Basic Organic Rankine Cycle (BORC) and Recuperative Organic Rankine Cycle (RORC) for waste heat recovery applications using pure refrigerants R-141b, R-245fa, R-123, and R-21. By performing simulations for heat source high-temperatures ranging from 160 to 200 °C. The comparison between BORC and RORC performance parameters and refrigerant properties was evaluated on the heat source temperature. Research shows that RORC produces higher thermal efficiency but has lower irreversibility than BORC. RORC has a maximum thermal efficiency of 12.67%, and BORC has a thermal efficiency of 11.49% for refrigerant R-141b at a flue gas temperature of 160 °C. The thermal efficiency of the ORC increases as the temperature of the heat source increases.
References
EBTKE,https://ebtke.esdm.go.id/post/2020/02/10/2473/kapasitas.pembangkit.naik. jadi.696.gw.ebt.sumbang.103.gw, Accessed: December 2021.
OUYANG T., HUANG G., et al., "Multi-criteria assessment and optimization of waste heat recovery for large marine diesel engines", Journal of Cleaner Production, v. 309, 2021.
ARIWIBOWO T.H., MIYARA A., “Thermal Characteristics of Slinky-Coil Ground Heat Exchanger with Discrete Double Inclined Ribs”, Resources, v. 9, 105, 2020.
MISHRA S., GHOSH A., RAI K., et al., "Dimensions of climate change and its consequences on ecosystem functioning", Global Climate Change, pp. 109–149. 2021.
PAPAPETROU M., KOSMADAKIS G., CIPOLLINA A., et al., “Industrial waste heat: Estimation of the technically available resource in the EU per industrial sector, temperature level and country”, Applied Thermal Engineering, v. 138, pp. 207-216. 2018.
LONI R., MAHIAN O., NAJAFI G., et al., “A critical review of power generation using geothermal-driven organic Rankine cycle”, Thermal Science and Engineering Progress, v. 25, 2021.
PERMANA D.I., RUSIRAWAN D., FARKAS, I., "A bibliometric analysis of the application of solar energy to the organic Rankine cycle", Heliyon, v. 8, n. 4, 2022.
LIU Q., “Waste Heat Recovery from Fossil-Fired Power Plants by Organic Rankine Cycles”, In: Organic Rankine Cycles for Waste Heat Recovery, pp. 120, 2019.
PAMBUDI N.A., "Geothermal power generation in Indonesia, a country within the ring of fire: Current status, future development and policy", Renewable and Sustainable Energy Reviews, v. 81, pp. 2893-2901, 2018.
ZHANG, J., DESIDERI, A., KAERN, M.R., et al., “Flow boiling heat transfer and pressure drop characteristics of R134a, R1234yf and R1234ze in a plate heat exchanger for organic Rankine cycle units”, International Journal of Heat and Mass Transfer, v. 108, pp. 1787–1801, 2017.
NIHAYAH H., SAKINA F.N., ARIWIBOWO T.H., SAFITRA A.G., “Performance Study of Organic Rankine Cycle (ORC) Using Low-Temperature Waste Heat With Zeotropic Refrigerants”, International Electronics Symposium (IES), 2022.
VERMA, H, PARMAR, Y., PRAJAPATI, P, "Study of effect of geometrical and thermodynamic variables on the performance of condenser in an organic rankine cycle", In: Materials Today: Proceedings, v. 46, 2021.
CHEN G., AN Q., WANG Y., et al.,” Performance prediction and working fluids selection for organic Rankine cycle under reduced temperature”, Applied Thermal Engineering, v. 153, pp. 95-103, 2019.
THURAIRAJA, K., WIJEWARDANE A., JAYASEKARA S., et al., “Working Fluid Selection and Performance Evaluation of ORC”, Energy Procedia, v. 156, pp. 244-248, 2019.
BAHRAMI, M., POURFAYAZ, F., KASAEIAN, A., "Low global warming potential (GWP) working fluids (WFs) for organic Rankine cycle (ORC) applications", Energy Reports, v. 8, pp. 2976-2988, 2022.
RAGHULNATH D., SARAVANAN K., MAHENDRAN J., et al., "Analysis and optimization of organic rankine cycle for IC engine waste heat recovery", In: Material Today: Proceedings 2019.
WEI D., LU X., LU G., et al., "Dynamic Modeling and Simulation of an Organic Rankine Cycle (ORC) System for Heat Recovery", Applied Thermal Engineering, v. 28, pp. 1216 – 1224, 2008.
SIMANJUNTAK M.E., “Pengaruh Excess Air Terhadap Kinerja PLTU Berkapasitas 12,5 MW Dengan Beban Bervariasi: Sebuah Simulasi Termodinamika Menggunakan Software CycleTempo Versi 5.0”, Rekayasa Mesin, v. 10, n. 3, pp. 287-289, 2019.
MUHAMMAD U., IMRAN M., LEE D.H., PARK B.S., "Design and experimental investigation of a 1 kW organic Rankine cycle system using R245fa as working fluid for low-grade waste heat recovery from steam", Energy Conversion and Management, v. 103, pp. 1089-1100, 2015.
HEBERLE F., PREIßINGER M., BRUGGEMANN D., "Zeotropic mixtures as working fluids in Organic Rankine Cycles for low-enthalpy geothermal resources", Renewable Energy, v. 37, pp. 364-370, 2012.
HOSSAIN F., MIAH M. A., " Utilization Of Organic Rankine Cycle For Analyzing Energy And Exergy Of The Waste Heat Recovery System ", Sigma Journal of Engineering and Natural Sciences, v. 38, pp. 1963- 1976, 2020
XU J., YU C., " Critical temperature criterion for selection of working fluids for subcritical pressure Organic Rankine cycles", Energy, v. 74, pp. 719-733, 2014
KIM K.H., KIM K. and KO H.J.," Entropy and Exergy Analysis of a Heat Recovery Vapor Generator for Ammonia-Water Mixtures", Entropy, v. 16, pp. 2056-2079, 2014
STANCIU D.D., SAGHEBIAN S.M., KURCHANIA A.,"The Influence of Condensing Temperature on the Efficiency of Solar Power Systems with ORC", Procedia Manufacturing, v. 46, pp. 359–363, 2020
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2023 Fara Nabilah Sakina, Habibatu Nihayah, Teguh Hady Ariwibowo, Lohdy Diana
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
